22″ Yard Machine Push Mower
WILL START AGAIN WHEN COLD
Experienced gardeners share their insights in answering this question :
Check your automatic choke … a cold mower needs more choke, and the auto-choke should release when the motor warms and runs smoothly. If the choke is sticking, the motor will die when it gets warmed up, then start again after it cools down.
How to Identify and Fix Common Gardening Problems ?
We provide a variety of viewpoints on how to identify and fix common gardening problems. Our sources include academic articles, blog posts, and personal essays from experienced gardeners :
Other things that could cause this issue are bad fuel, weak/colapsed/kinked fuel line, faulty spark plug, faulty ignition/coil, oil over full, clogged air filter, plugged/dirty carburetor, worn engine parts internal rings/valves/etc.
A Dirty Carburetor Can Cause a Lawnmower To Start Then Die
By far, the most common issue that causes a stalled motor is a dirty carburetor. The carburetor on your engine is the thing that draws in air and mixes it with the fuel. Contrary to what the movies might make you think, gasoline itself is not very flammable.
Condensation inside the gas tank is one culprit, but moisture can also enter the system through a loose or ill fitting gas cap. The best solution is to drain the mower`s gas tank and refill it with fresh gasoline. A clogged fuel filter can also cause a mower engine to die.
A full gas tank and oil reservoir are the essential first steps when checking why the lawn mower won`t stay running, but the problem could also be a dirty filter, clogged carburetor, improper fuel mixture, or a dirty spark plug.
If your lawn mower starts, runs briefly, then dies these are the four most common reasons that`s happening: Dirty carburetor / clogged carburetor bowl. Old gasoline that has gone bad. Dirty or defective spark plugs.
Your lawn mower runs for 30 minutes then dies if you are having issues such as a bad spark plug, air problems, a malfunctioning carburetor, or a faulty gas cap. You may even encounter the issue that your lawn mower runs for 5 minutes then dies.
Use Carburetor Cleaner
Fortunately, you can generally do this without even taking the carburetor out of the engine. Start by purchasing some commercial lawnmower carburetor cleanerOpens a new window, which comes in a simple spray can and will make it easy to clean the inside and outside of the carb.
You Lose Power in the Middle of Mowing:
Here`s why this happens and what you can do: Dirty Air Filter on Your Lawn Mower: Clean or replace. Dirty Spark Plug: Clean or replace. Build Up of Clippings & Debris: Clean underside of your lawn mower deck as noted above.
Mower Gas Cap
If the tank is sealed, the fuel becomes air locked, and the mower stalls. This typically happens after a short period between ten and thirty minutes and also depends on factors like weather and gas tank fuel level.
The most common reason for a surging lawn mower engine is a blockage in the fuel supply, but there are other possibilities: Bad gas. Bad spark plug. Dirty/faulty carburetor.
A lawn mower that only runs with the choke on might be having problems with the carburetor, air supply, or bad fuel. Maintaining a clean carburetor will make the fuel delivery system run smoothly. Use high-quality fuel to extend the lawn mower`s life.
A dirty air filter is one of the most common causes of a poorly running lawn mower, since it starves the engine of the oxygen needed for combustion. Fuel Filter: Check the fuel filter on the mower to make sure it`s clean, and replace it if needed.
A clogged carburetor is most commonly caused by leaving fuel in the lawn mower for a long period of time. Over time, some of the ingredients in the fuel may evaporate, leaving behind a thicker, stickier substance. This sticky fuel can clog up the carburetor and cause the engine to stall.
An easy solution is to remove the mower casing and clean it of dirt and debris. Low Oil Levels can also cause overheating. With not enough oil circulating, internal friction occurs preventing heat from not being reduced. Be sure to check your oil level each time before you start your machine, and add oil if needed.
How long do they last? Most mowers will run 10 years or more with regular maintenance. Warranties are two to five years.
Your lawnmower may stop running when hot due to an overheated engine, air leaks, a clogged fuel system, or the carburetor not getting enough gas. It is also possible that the engine is not cooling as it runs because of a dirty air filter. Finally, worn-out pistons may also be the problem.
Your lawnmower may stop running when hot due to an overheated engine, air leaks, a clogged fuel system, or the carburetor not getting enough gas. It is also possible that the engine is not cooling as it runs because of a dirty air filter. Finally, worn-out pistons may also be the problem.
As the fuel level drops, a vacuum begins to form in the fuel tank because air can get in to fill the space the consumed fuel occupied. After about 10 or 15 minutes, the vacuum will become strong enough that fuel will stop flowing to the carburetor and the lawnmower will die.
Discover Relevant Questions and Answers for Your Specific Issue
the most relevant questions and answers related to your specific issue
It won’t stay running. have cleaned the gas tank and it just had a tune up. runs fine then gets rough and quits. If I push the bulb it smooths out and runs fine for a couple of minutes and then begins hesitating again. Now today it ran for about 15 min. and now it won’t start. It wants to. runs for a couple of seconds 5-10 and then quits.
ANSWER : Remove the float bowl and empty the contents out clean and replace
Read Full Q/A … : 22″ Yard Machine Push Mower
Self propelled mower will start but want stay running long? it runs about 3 or 4 min. then stop and when i restart it, it will start back up.
ANSWER : The fuel bowl has a float and needle, if the float isn’t floating to open the needle for gas to flow into the carb, it will cut off. A kit can be purchased for about $5 or take yours out and soak and clean then replace. Usually when these go bad its best to replace them.
Read Full Q/A … : 22″ Yard Machine Push Mower
Lawn mower will start and run for 5 seconds and shut down
ANSWER : Will it stay running with your choke on? if so then clean your carb. if not then look for a blockage from tank to carb. ie fuel shut off, deteriorated fuel line. plugged filter etc
Read Full Q/A … : 22″ Yard Machine Push Mower
Carb problems wont stay running unless i unplug and plug in the anti diesel switch the plug on the fuel bowl
ANSWER : Check and see if all your carb jets or clean sound like some dirt got into one
Read Full Q/A … : 22″ Yard Machine Push Mower
I have a Poulan push mower that after mowing in a ditch started making a loud noise and running rough. It almost sounded as if metal was hitting metal. The mower was vibrating more than normal. I checked under the mower and nothing is hitting. After a few times of stopping the mower engine because it sound as if it is going to die down the mower will not start now. The shaft does not appear bent and the blade appears ok. The mower has oil, a good spark plug and a clean air filter. It was running fine until that moment. I did not see anything that I hit but it is possible I hit something in the ditch like a pine cone or branch. What could the problem be and how would I go about fixing it?
ANSWER : If you are sure the oil level is correct then it sounds like it’s about to die, unfortunately. A pine cone shouldn’t cause any damage, but a large branch may do so. Was it smoking before you shut it down? The vibration could be caused from a bent blade. It could also be caused from a part breaking in the motor. I wish I could have given you better news!
Good Luck,
Jim
Read Full Q/A … : 22″ Yard Machine Push Mower
Lawn mower cranck but wont start…
ANSWER : Since you already checked for spark and air I would drain all the fuel out of it and check that fuel for water. Over time some lawn mowers end up with contaminated fuel. You can see the water sitting on the bottom of the fuel if you let it stand for a bit in a small plastic bowl.
Be sure to empty and dry out you fuel can as well. Especially if the mower stopped running right after a refuel. Which is a good sign your gas can is contaminated too.
Read Full Q/A … : 22″ Yard Machine Push Mower
Mower start up and runs, but starts to cut back, and smokes just a little bit. The mower stops smoking when it throttle up. It will continue to run but not at full throttle. I can hold a finger gently over the fuel primer bulb and it will throttle up for a small time.
ANSWER : It sounds like she’s being deprived of the correct fuel / air mixture due to a dirty carburetor (the biggest problem with mowers when gas is left to sit for a period of time). If you do not know how to take the carburetor apart and clean it thoroughly, then I suggest taking it to the local shop (hardware store or mower shop) and having it tuned up. It’ll probably be just fine and worth the money. Hope this helps and good luck.James
Read Full Q/A … : 22″ Yard Machine Push Mower
I have had a poulan pro 550 series push mower for almost 1 year at the end of the season last year the mower would start briefly and then stop. i have cleaned out the air filter and that did not help.the mower started, i made one revolution around the yard 3/4th of the way the mower quit. I then primed the mower it started then quit and now it will not start at all. Does anyone have any suggestions of what to do. Thanks
ANSWER : There is a little spring that works the carburetor arm. If that popped off then the mower will not run.
Read Full Q/A … : 22″ Yard Machine Push Mower
