Honda

This motor is on a go kart and it came off of an air compressor. Once u press on the gas running it wide open it starts to bog down and cut out then if u keep patting the gas it livens up and keeps going. However if u take it on level ground or up a hill and make a right turn it shuts off.

How to Identify and Fix Common Gardening Problems ?

We provide a variety of viewpoints on how to identify and fix common gardening problems. Our sources include academic articles, blog posts, and personal essays from experienced gardeners :

The carburetor might be clogged. A clogged carburetor is most commonly caused by leaving fuel in the engine for a long period of time. Over time, some of the ingredients in the fuel may evaporate, leaving behind a thicker, stickier substance. This sticky fuel can clog up the carburetor and cause the engine to stall.
The Honda GX160 engine has an oil capacity of 0.6 liters. These small mechanical engines should have the oil level checked every 50 hours.
The most common reason your car starts then dies immediately is because of a lack of fuel in the engine. This often happens because there is a small amount of fuel in the fuel rail, which helps to start the engine. However, there is no fuel pressure to keep the engine running.
The Honda idle-stop feature maximizes your fuel efficiency when your vehicle is idling. If you`re stationary for more than two seconds, such as in stop-and-go traffic, the engine will shut off; many of the vehicle`s functions, such as the A/C, will continue to power on smoothly.
Q: How Do I Know if My Carburetor Needs Adjusting? A: Simply put, poor running conditions are a dead giveaway. A rough idle, poor throttle response, and excessive fuel consumption are all signs to look for. If the carburetor was sitting for some time or hasn`t been serviced in a while, you may need to clean it first.
Honda Gx 160cc TOP SPEED 60km/h racing go kart.
The Honda 163cc GX160 Series horizontal engine produces 7.6-pound-Feet (10.3 Nm) at 2,500 rpm net torque.
Honda Powered water blaster Honda GX160 4.8 hp 179 bar (2600 psi) 9 lpm.
Being a 4-stroke engine, it means that it meets the worlds most stringent environmental legislation and emits very few emissions, has low fuel and oil consumption and reduced vibration and noise levels.
Engines usually stop suddenly only if they suffer from a lack of fuel or sparks . An engine that stops dead without prior warning has probably had a sudden ignition failure – although if it locks solid it`s more likely to have seized.
There are three major causes for a stalled engine: A lack of fuel, a lack of air flow and improper ignition. Running out of fuel is one of the most common causes of engine stalling, but dirty fuel injectors or a plugged fuel filter can also be the culprit.
The most common and obvious reason your car may start then die is the fuel shortage in your engine. This happens because there`s not enough fuel in the fuel rail, and there`s no fuel pressure to keep the engine alive. The reason isn`t always you forgetting to fill up your gas tank.
A lack of fuel pressure or fuel volume can easily lead to engine stalling. Common culprits include a faulty fuel pump or fuel pump relay. A clogged fuel filter or bad fuel pressure regulator is also common on return-type fuel systems. Another often overlooked problem is the vehicle simply being out of fuel.
A Dirty Carburetor Can Cause a Lawnmower To Start Then Die

By far, the most common issue that causes a stalled motor is a dirty carburetor. The carburetor on your engine is the thing that draws in air and mixes it with the fuel. Contrary to what the movies might make you think, gasoline itself is not very flammable.

A lack of fuel pressure or fuel volume can easily lead to engine stalling. Common culprits include a faulty fuel pump or fuel pump relay. A clogged fuel filter or bad fuel pressure regulator is also common on return-type fuel systems. Another often overlooked problem is the vehicle simply being out of fuel.

Discover Relevant Questions and Answers for Your Specific Issue

the most relevant questions and answers related to your specific issue

Hello i have a Honda GX160 and the engine will only run on choke if i close it the engine just splutters and thats it. it wont run at the norm i have replaced the carb the tank the air filter and the spark plug and know luck i have no more ideas as to what the problem really is thanks jord
ANSWER : Ii know you must have replaced the fuel filter. Did you replace the fuel line? It is obvious it is not betting enough fuel or it is out of time. Have you tried adjusting the jets on the carb? Have you checked the timing? There is a crankshaft key-way that may be bent just enough to get the engine out of time. And finally have you checked the fuel pump which I would suspect is your problem. The diaphragm may be busted.

Read Full Q/A … : Honda

My Honda 160cc lawn mower engine cut out when I hit a large clump of grass. Now I cannot get it to start. Has always started with no problems. What to do?
ANSWER : Has probably broken flywheel key ….. putting it out of time

Read Full Q/A … : Honda

Honda powered gx160 model pressure washer wont start
ANSWER : Did you drain out the fuel before you stock it? If you didn’t, you may need to clean the carburetor or replace a new one because the fuel inside has become a kind of stick varnish. You may take a look at following link to see how to change or replace a carburetor. http://solosmallengine.blogspot.com

Read Full Q/A … : Honda

Gx160 Pressure Washer runs fine for 20 seconds Then shuts off
ANSWER : Check for stuck float, plugged fuel filter or fuel line. All tanks have a screen inside them to catch larger particles, and some also have a inline fuel filter. If everything checks ok, the passages inside the carb are plugged, follow the cleaning procedure outline in the manual to be sure you only have to do the job once!
Take a look at following link to see more solution to different small engine problems. http://solosmallengine.blogspot.com/

Read Full Q/A … : Honda

<!– from fixya rte –>Electrical diagram for Honda GX390 – Honda Gx390 Motor Inside Cover
ANSWER : Check out the manual here http://cdn.powerequipment.honda.com/engines/pdf/manuals/37Z5F602.pdf

Read Full Q/A … : Honda

How do i get a honda lawn mower engine repair manual
ANSWER : Http://www.hondapowerequipment.com/products/manuals/Default.aspxafter finding your lawn mower then click trouble shooting manual on your left side and have a nice weekend

Read Full Q/A … : Honda

I have a Husqvarna 5521CHV lawn mower. it stars easy but then cuts off in a few seconds. but will restart easy.
ANSWER : I don’t have a solution but have the same problem. When choke opens the engine shuts down.

Read Full Q/A … : Honda

I have a honda gx160 motor it starts and runs but its knocking what is wrong and what should i do?
ANSWER : Is the air filter dirty? With the bowl as the lowest part of the fuel system, any dirt or water will wind up here. Turn off the fuel valve, or drain the gas tank, then place a rag under the bowl to catch the gas that will run out. Loosen the “nut” that holds the bowl on, and after the gas has stopped draining remove the nut and bowl, but do not let the float swing all the way down! Wipe out the bowl. The “nut” usually contains 1 or 2 very small passages, soak in (or spray with) carb cleaner and use a wire bread-tie or other soft wire to poke out the holes. Blow out with compressed air, if available. Put the bowl back on and try to start it. If it still will not start, it needs a good soaking and a rebuild kit. Take a look at following link to see more solution to different small engine problems. http://solosmallengine.blogspot.com/

Read Full Q/A … : Honda